Grenade Launchers and their Ammunition: International Developments

18 Pages·2015·2.66 MB·English

GRENADE LAUNCHERS AND THEIR AMMUNITION:
INTERNATIONAL DEVELOPMENTS

© Anthony G Williams

This article is based on various presentations given in 2013-15 and on
articles published in Jane's International Defence Review (November
2013) and in Small Arms Defense Journal (Vol.7 No.1)

Grenade launchers and their ammunition are currently experiencing the
fastest and most dramatic period of development of any small arms. This
article will provide a summary of shoulder-fired and crew-served
grenade launchers, concentrating on developments in ammunition types.

NATO 40mm Systems
NATO is currently focused on the 40mm calibre for under-barrel or
stand-alone shoulder-fired launchers and also for crew-served automatic
launchers. However, while the calibre is standard, there are now four
different performance levels to choose from. Two are long-established,
dating back to the Vietnam War: the 40mm Low Velocity (or LV) which
uses 40 x 46SR (Semi-Rimmed) ammunition in shoulder-fired or
underbarrel launchers, and the 40mm High Velocity (or HV), which fires
40 x 53SR rounds from crew-served automatic launchers.
40mm LV ammunition is currently made by about 25 different companies
in 18 countries, in a wide range of lethal, less-lethal and other natures.
Apart from conventional HE and HEDP these include thermobaric HE,
HE Jump (a low-cost airburst, in which a small nose charge fires on
impact, kicking the grenade a couple of metres into the air before it
explodes), and HE anti-diver, designed to explode underwater. Non-
explosive loadings include shot loads, smoke, illuminating and signal
flares, a huge range of less-lethal ammunition matching that available in
37mm riot guns and including both impact and chemical types (the latter
for non-military use), and even reconnaissance projectiles – the
SPARCS from STK has a parachute-borne camera.
The universality of the ammunition means that there are numerous
stand-alone and underbarrel launchers made to fire it. The M79 was the
classic single-barrel stand-alone type but this has largely been replaced
1
by underbarrel launchers such as the M203, which is itself being
replaced in the US and other armies by more modern underbarrel
launchers like the L123A1 and M320 from Heckler & Koch, which can
fire a wider range of munitions and can be fitted with a stock and sights
for the stand-alone role. When more firepower is required, six-shot
revolvers such as the USMC's M32 are also available from several
companies, at the cost of significant bulk and weight.

40mm HV ammunition is made by some 15 companies in a dozen
countries. It fires grenades which are typically 30 percent heavier than
the LV at three times the muzzle velocity, increasing the maximum
ballistic range from 400 to over 2000 metres (although the effective
maximum is significantly less in both cases). Recoil is several times
greater, which means that attempts to design shoulder-fired weapons for
this cartridge have so far been unsuccessful, although NORINCO of
China recently announced one. The ammunition is therefore used in
crew-served, tripod-mounted, belt-fed launchers generally known as
automatic grenade launchers or AGLs. The original launcher was the
MK19 which is still very much in use, although more recently a wide
range of competitors has emerged, most notably the GMG (Grenade
Machine Gun) from Heckler & Koch, in service with fifteen countries.
There is much less variety than with LV in the types of ammunition
2
available, owing to the requirement to fit into the ammunition feed and to
develop a certain level of recoil to operate the launcher, so
HE/fragmentation or HEDP are the standard natures.

In recent years two new performance levels have been introduced for
shoulder-fired launchers. The first of these is the Medium Velocity or MV
ammunition, intended to provide a greater effective range than LV plus a
larger and more destructive grenade. Cartridge case lengths vary from
46 to 51mm. The first of these were from Martin Electronics (now part of
the Chemring Group), with Rheinmetall also developing MV rounds. The
heavier grenades fired at a higher muzzle velocity result in a maximum
ballistic range in the region of 700-800 metres, and when fired at shorter
ranges have a much flatter trajectory and shorter flight time than LV
rounds, considerably improving their hit probability. However, the
additional recoil can be considerable, especially in lighter weapons, so
this ammunition is currently best suited to the solid and heavy six-barrel
revolver type launchers; in fact, the Rheinmetall rounds have a modified
case rim to prevent their use in unmodified LV launchers.
As a result of the recoil problem, some manufacturers, namely Arcus of
Bulgaria, STK of Singapore and Rheinmetall again, have introduced
what is now usually called Low Velocity Extended Range ammunition
(LV-ER), which sits in between the low and medium velocity types and is
3
specifically intended for under-barrel or single-barrel launchers. These
typically have maximum ballistic ranges of 600+ metres.
While the performance of HV and to some extent LV rounds is
standardised, that's not the case with MV and LV-ER ammunition, to
which different manufacturers have different approaches. The first MV
rounds used new grenade designs but Rheinmetall has adopted a
simpler solution with their Velan range, which fires their standard HV
grenades from a lower-powered cartridge. In contrast, all of the LV-ER
makers combine their standard LV grenades with higher-powered
cartridges, but the muzzle velocity and range vary.

The table above summarises some typical characteristics of 40mm
ammunition, but it should be borne in mind that the characteristics of MV
and LV-ER ammunition do vary. It should be noted that the weights
quoted here are for the grenades only, not the complete rounds, and that
ranges are maximum ballistic figures; the effective ranges against area
targets would be around two-thirds of these figures, against point targets
less than half. The two columns on the right indicate the relative recoil
impulse of the four types, and their free recoil energy if the ammunition
was fired in guns of the same type and weight.
So far, there seems to have been much interest but few contracts for MV
and LV-ER ammunition, but that may change in the future.

4
Other Grenade Systems
Beyond NATO, the main supplier of grenade launchers is Russia,
although China is catching up. The Russian equivalent to the NATO low-
velocity round is the VOG-25 series, another 40mm of similar
performance, but differing technically in being caseless - the propellant
is contained within a small element attached to the back of the grenade
that travels with it. As with the NATO LV, a very wide range of munitions
is available for it. The muzzle-loading GP-25 and GP-30 are the
standard launchers, but there are also six-shot revolvers and an
interesting three shot Arcus repeater with the tubular magazine in the
shoulder stock.

The Russian equivalent to the high-velocity round is the VOG-17 series
which uses a conventional cartridge but differs in being of only 30mm
calibre. However, the projectile is unusually long and similar in weight to
the NATO 40mm HV. The maximum ballistic range was originally a few
hundred metres less than the NATO HV, but recent ammunition
developments have seen this increase to more than 2,000 metres. Apart
from the automatic belt-fed AGS-17 and AGS-30 launchers from Russia,
Slovakia offers a shoulder-fired magazine-fed bipod-mounted weapon
using this 30 x 29B (Belted) round, the RAG-30, which offers an
interesting level of portable firepower as it weighs only 12 kg (26½ lbs).
5
6
Russia also produces some oddities, including two different 30mm
captive-piston under-barrel systems for special forces which are virtually
silent when fired. The BS-1 uses a conventional blank cartridge to drive
a captive piston forwards in the launcher (the trapped gases need to be
bled off before the launcher can be reloaded). The BMYa-31 uses a
special blank round that incorporates its own captive piston (the blank
containing the sealed-in gases can be ejected and the launcher reloaded
immediately). Maximum ranges are 300-400 metres.
Also in use in Russia is the 43mm GM-94 stand-alone launcher that
resembles an oversized pump-action shotgun and fires VGM-93
ammunition at ranges of up to 600 metres. The ammunition is mostly
less-lethal but includes a thermobaric HE round, presumably for the
more emphatic dispersal of rioting crowds.
Russia has reportedly introduced into service, apparently for special
forces, the 40mm Balkan AGL that fires unique caseless grenades,
much bigger and heavier than the VOG-25 series. These rounds weigh
450 g and contain 90g HE which, in conjunction with the 2,500m
maximum range, amounts to a better on-paper performance than the
NATO AGLs.

7
China initially adopted Russian equipment but has now developed its
own in 35mm calibre. There are three different, incompatible series of
35mm grenades and associated launchers. Two of them are low-velocity
types for underbarrel grenade launchers: the caseless low-velocity
35mm DFS10 round for the army's QLG10 launcher, which is like a
slimmed down VOG-25 and has a similar performance, and the Type 91
UBGL firing plastic-cased ammunition, which is mainly used with less-
lethal grenades for riot control.

The best-known Chinese grenade is the conventional 35 x 32SR high-
velocity DF87 series ammunition which has a ballistic range of 1,750
metres. The HEDP grenade, which is slightly heavier than NATO's
40mm HV, is claimed to penetrate 80mm armour plate as well as having
a lethal radius of 11 metres. It is used in a pair of automatic launchers,
the belt-fed, tripod mounted QLZ04 which weighs 55 lbs including tripod
(about half that of the MK19) and the even lighter, magazine-fed QLZ87
which is available bipod or tripod mounted and weighs only 44 lbs with a
tripod, 26½ lbs on a bipod.
8
9
The most interesting weapon using the 35 x 32SR round is the
lightweight semi-automatic QLZ87B (now known as QLB06), which has
a 1,000m range against area targets and 600m against point targets.
This offers a combination of firepower, range and light weight (only 9.1
kg - 20 lbs empty) not approached by anything except the RAG-30.
Much is said about achieving "overmatch" over potential opponents, and
this weapon provides an example of what that means in portable
grenade launchers. The QLZ87 and QLB06 seem to have been widely
distributed to third-world countries since they have been spotted in Africa
(in Sudan, Chad and Uganda) and the Middle East (in the hands of
Syrian insurgents) as well as South America, so NATO troops may well
be on the receiving end of their fire in future conflicts.

The table above provides the basic data for the Russian 40mm low-
velocity caseless VOG-25, the high-velocity 30mm VOG-17, the Chinese
35mm low-velocity DFS10 and their 35mm high-velocity DF87 series.
The recoil figures quoted are calculated on the same basis as for the
NATO grenades in the table shown earlier, in which you may recall that
the 40mm HV round developed a recoil energy figure of 17.6,
significantly greater than either the Russian or Chinese high-velocity
rounds, which makes it much more difficult for shoulder-fired launchers
10