Supplement Airplane Maintenance Manual

156 Pages·2011·4.36 MB·French

Thielert Aircraft Engines GmbH Tel. [phone]
Fax [phone]
Platanenstraße 14
www.centurion-engines.com
D - 09350 Lichtenstein
[email protected]
Supplement
Airplane Maintenance
Manual
Cessna 172
TAE 125-01
Doc. No.: AMM-20-01
Version: 2/16
CAUTION:
(cid:132)
This Supplement to the Airplane Maintenance Manual must
be read completely before maintenance action, as it
contains important safety information.
CAUTION:
(cid:132)
The organizations and staff who carry out these
maintenance action must be approved by the authority,
with the exception of the “Pre-flight check“
Note:
(cid:139)
The Supplement to the Airplane Maintenance Manual is to
be included at every Cessna 172 / TAE 125-01 installation
Note:
(cid:139)
Please report any service difficulties to the Technical
Support Center at Thielert Aircraft Engines GmbH.
See above for contact information.
This page intentionally blank
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
Table of Contents
0.1 LIST OF REVISIONS....................................................1
0.2 LIST OF APPLICABLE CHAPTERS.............................4
1 INTRODUCTION...........................................................1
1.1 ACCOMPANYING APPLICABLE DOCUMENTS .........1
1.2 IDENTIFICATION OF PARTS OF TAE 125-01
INSTALLATION.............................................................2
1.3 COPYRIGHT ©.............................................................4
1.4 CONVENTIONS IN THIS MANUAL..............................4
1.5 VALIDITY OF THIS MANUAL.......................................4
1.6 ABBREVIATIONS.........................................................5
1.7 PACKING AND TRANSPORT......................................5
1.8 STORAGE.....................................................................5
1.9 QUALIFICATIONS OF THE OPERATING AND
MAINTENANCE PERSONNEL.....................................5
1.10 UPDATE INFORMATION SERVICE.............................5
1.11 SERVICE LIFE OF THE ENGINE.................................5
1.12 CONVERSION FACTORS............................................6
4 AIRWORTHINESS LIMITATIONS, REVISION 2 .........1
4.1 ENGINE LIFE LIMIT......................................................1
4.2 MANDATORY MAINTENANCE ACTIONS...................1
4.3 LOG OF REVISIONS TO AIRWORTHINESS
LIMITATIONS................................................................2
5 TIME LIMITS / MAINTENANCE CHECKS...................1
5.10 TIME LIMITS.................................................................2
5.20 SCHEDULED MAINTENANCE CHECKS.....................2
5.50 UNSCHEDULED MAINTENANCE................................5
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Revision no.: 12 Page: 1
Revision date: 15.10.2010 Content: 4
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
6 DIMENSIONS AND AREAS.........................................1
6.1 MODEL .........................................................................1
6.2 ENGINE ........................................................................1
6.3 PROPELLER.................................................................2
6.4 FUEL SYSTEM.............................................................2
12 SERVICING ..................................................................1
12.00 GENERAL.....................................................................1
12.10 REPLENISHING ...........................................................2
12.20 SCHEDULED SERVICING...........................................5
20 STANDARD PRACTICES - AIRFRAME......................1
20.00 GENERAL.....................................................................1
20.10 Standard Torque Values...............................................1
20.20 Firewall Sealants...........................................................3
21 ENVIRONMENTAL SYSTEMS.....................................1
21.00 GENERAL.....................................................................1
24 ELECTRICAL POWER.................................................1
24.00 GENERAL.....................................................................1
24.30 DC GENERATION........................................................2
24.50 ELECTRICAL LOAD DISTRIBUTION...........................9
28 FUEL.............................................................................1
28.00 GENERAL.....................................................................1
28.20 DISTRIBUTION.............................................................2
28.40 INDICATING ...............................................................10
31 INDICATING / RECORDING SYSTEMS......................1
31.50 CENTRAL WARNING SYSTEMS.................................1
31.60 INDICATING INSTRUMENTS .....................................2
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Page: 2 Revision no.: 12
Content: 4 Revision date: 15.10.2010
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
37 VACUUM ......................................................................1
37.00 GENERAL.....................................................................1
61 PROPELLER................................................................1
61.10 CONSTANT SPEED PROPELLER...............................1
61.20 CONSTANT SPEED UNIT............................................2
71 POWER PLANT............................................................1
71.00 GENERAL.....................................................................1
71.20 MOUNTS.....................................................................23
71.40 ATTACH FITTINGS ....................................................25
71.60 AIR INTAKES .............................................................27
73 ENGINE FUEL SYSTEM..............................................1
73.00 GENERAL.....................................................................1
74 IGNITION......................................................................1
74.00 GENERAL.....................................................................1
75 LIQUID COOLING........................................................1
75.00 GENERAL.....................................................................1
77 ENGINE INDICATION ..................................................1
77.00 GENERAL.....................................................................1
78 EXHAUST.....................................................................1
78.00 GENERAL.....................................................................1
79 OIL................................................................................1
79.00 GENERAL.....................................................................1
79.30 INDICATING .................................................................4
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Revision no.: 12 Page: 3
Revision date: 15.10.2010 Content: 4
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
80 STARTING....................................................................1
80.00 GENERAL.....................................................................1
91 CHARTS AND WIRING DIAGRAMS ...........................1
91.10 WIRING DIAGRAMS.....................................................1
91.20 SPECIAL TOOLS........................................................11
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Page: 4 Revision no.: 12
Content: 4 Revision date: 15.10.2010
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
0.1 LIST OF REVISIONS
Chapter Issue/Revision Date Approved by
20-MM-00-01 1/1 02.10.03 Gutzmann
20-MM-01-01 1/1 02.10.03 Gutzmann
20-MM-02-01 1/1 02.10.03 Gutzmann
AMM-20-00 2/0 02.06.04 Gutzmann
AMM-20-05 2/0 02.06.04 Gutzmann
AMM-20-06 2/0 02.06.04 Gutzmann
AMM-20-12 2/0 02.06.04 Gutzmann
AMM-20-21 2/0 02.06.04 Gutzmann
AMM-20-24 2/0 02.06.04 Gutzmann
AMM-20-28 2/0 02.06.04 Gutzmann
AMM-20-31 2/0 02.06.04 Gutzmann
AMM-20-37 2/0 02.06.04 Gutzmann
AMM-20-39 2/0 02.06.04 Gutzmann
AMM-20-61 2/0 02.06.04 Gutzmann
AMM-20-71 2/0 02.06.04 Gutzmann
AMM-20-73 2/0 02.06.04 Gutzmann
AMM-20-74 2/0 02.06.04 Gutzmann
AMM-20-77 2/0 02.06.04 Gutzmann
AMM-20-78 2/0 02.06.04 Gutzmann
AMM-20-79 2/0 02.06.04 Gutzmann
AMM-20-80 2/0 02.06.04 Gutzmann
AMM-20-91 2/0 02.06.04 Gutzmann
AMM-20-00 2/1 13.08.04 Gutzmann
AMM-20-05 2/1 13.08.04 Gutzmann
AMM-20-00 2/2 22.10.04 Gutzmann
AMM-20-04 2/0 22.10.04 Gutzmann
20-AMM-00-01 2/3 22.11.2004 Gutzmann
20-AMM-01-01 2/1 22.11.2004 Gutzmann
20-AMM-04-01 2/1 22.11.2004 Gutzmann
20-AMM-05-01 2/2 22.11.2004 Gutzmann
20-AMM-06-01 2/1 22.11.2004 Gutzmann
20-AMM-12-01 2/1 22.11.2004 Gutzmann
20-AMM-21-01 2/1 22.11.2004 Gutzmann
20-AMM-24-01 2/1 22.11.2004 Gutzmann
20-AMM-28-01 2/1 22.11.2004 Gutzmann
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Revision no.: 16 Page: 1
Revision date: 16.03.2012 Content: 4
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
Chapter Issue/Revision Date Approved by
20-AMM-31-01 2/1 22.11.2004 Gutzmann
20-AMM-37-01 2/1 22.11.2004 Gutzmann
20-AMM-61-01 2/1 22.11.2004 Gutzmann
20-AMM-71-01 2/1 22.11.2004 Gutzmann
20-AMM-73-01 2/1 22.11.2004 Gutzmann
20-AMM-74-01 2/1 22.11.2004 Gutzmann
20-AMM-77-01 2/1 22.11.2004 Gutzmann
20-AMM-78-01 2/1 22.11.2004 Gutzmann
20-AMM-79-01 2/1 22.11.2004 Gutzmann
20-AMM-80-01 2/1 22.11.2004 Gutzmann
20-AMM-91-01 2/1 22.11.2004 Gutzmann
20-AMM-00-01 2/4 19.05.2005 Gutzmann
20-AMM-04-01 2/2 19.05.2005 Gutzmann
20-AMM-05-01 2/3 19.05.2005 Gutzmann
20-AMM-28-01 2/2 19.05.2005 Gutzmann
20-AMM-91-01 2/2 19.05.2005 Gutzmann
20-AMM-00-01 2/5 22.12.2005 Bollen
20-AMM-05-01 2/4 22.12.2005 Bollen
20-AMM-00-01 2/6 09.06.2006 Bollen
20-AMM-04-01 2/3 09.06.2006 Bollen
20-AMM-06-01 2/2 09.06.2006 Bollen
20-AMM-28-01 2/3 09.06.2006 Bollen
20-AMM-00-01 2/7 30.06.2006 Bollen
20-AMM-61-01 2/2 30.06.2006 Bollen
20-AMM-00-01 2/8 14.07.2008 van den Bosch
20-AMM-01-01 2/2 14.07.2008 van den Bosch
20-AMM-05-01 2/5 14.07.2008 van den Bosch
20-AMM-06-01 2/3 14.07.2008 van den Bosch
20-AMM-12-01 2/2 14.07.2008 van den Bosch
20-AMM-21-01 2/2 14.07.2008 van den Bosch
20-AMM-24-01 2/2 14.07.2008 van den Bosch
20-AMM-28-01 2/4 14.07.2008 van den Bosch
20-AMM-31-01 2/2 14.07.2008 van den Bosch
20-AMM-71-01 2/2 14.07.2008 van den Bosch
20-AMM-61-01 2/3 14.07.2008 van den Bosch
20-AMM-79-01 2/2 14.07.2008 van den Bosch
20-AMM-91-01 2/3 14.07.2008 van den Bosch
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Page: 2 Revision no.: 16
Content: 4 Revision date: 16.03.2012
Supplement Airplane Maintenance Manual
Cessna 172 / TAE 125-01
AMM-20-01
Chapter Issue/Revision Date Approved by
20-AMM-00-01 2/9 08.09.2009 van den Bosch
20-AMM-05-01 2/6 08.09.2009 van den Bosch
20-AMM-20-01 2/0 08.09.2009 van den Bosch
20-AMM-61-01 2/4 08.09.2009 van den Bosch
20-AMM-71-01 2/3 08.09.2009 van den Bosch
20-AMM-00-01 2/10 26.01.2010 van den Bosch
20-AMM-01-01 2/3 26.01.2010 van den Bosch
20-AMM-05-01 2/7 26.01.2010 van den Bosch
20-AMM-06-01 2/4 26.01.2010 van den Bosch
20-AMM-24-01 2/3 26.01.2010 van den Bosch
20-AMM-28-01 2/5 26.01.2010 van den Bosch
20-AMM-91-01 2/4 26.01.2010 van den Bosch
20-AMM-00-01 2/11 01.06.2010 van den Bosch
20-AMM-04-01 2/4 01.06.2010 van den Bosch
20-AMM-12-01 2/3 01.06.2010 van den Bosch
20-AMM-24-01 2/4 01.06.2010 van den Bosch
20-AMM-28-01 2/6 01.06.2010 van den Bosch
20-AMM-00-01 2/12 15.10.2010 van den Bosch
20-AMM-28-01 2/7 15.10.2010 van den Bosch
20-AMM-91-01 2/5 15.10.2010 van den Bosch
20-AMM-00-01 2/13 01.03.2011 van den Bosch
20-AMM-01-01 2/4 01.03.2011 van den Bosch
20-AMM-24-01 2/5 01.03.2011 van den Bosch
20-AMM-75-01 2/1 01.03.2011 van den Bosch
20-AMM-79-01 2/3 01.03.2011 van den Bosch
20-AMM-00-01 2/14 13.04.2011 van den Bosch
20-AMM-06-01 2/5 13.04.2011 van den Bosch
20-AMM-00-01 2/15 30.06.2011 van den Bosch
20-AMM-05-01 2/8 30.06.2011 van den Bosch
20-AMM-06-01 2/6 30.06.2011 van den Bosch
20-AMM-24-01 2/6 30.06.2011 van den Bosch
20-AMM-79-01 2/4 30.06.2011 van den Bosch
20-AMM-00-01 2/16 16.03.2012 Bollen
20-AMM-00-05 2/9 16.03.2012 Bollen
20-AMM-00-06 2/7 16.03.2012 Bollen
Chapter: 20-AMM-00-01
Issue: 2
Issue date: 02.06.2004
Revision no.: 16 Page: 3
Revision date: 16.03.2012 Content: 4